The wind resistance of asphalt roofing shingles.

摘要

Asphalt shingle roofing is the leading cause of hurricane wind-related insured losses in residential buildings. Damage statistics generated from recent hurricanes indicate shingle roofs sustain damage in wind velocities below design-level with damage frequency increasing with shingle roof age. The objective of this dissertation is the identification of primary mechanisms triggering the failure of shingle roof systems in wind. The research goal is to reduce future shingle roof wind damage and improve our ability to predict asphalt shingle wind resistance. Five studies comprising this dissertation addressed the adhesive consistency and strength of aged asphalt shingles, system-level wind resistance, and the load model underpinning the ASTM D7158 wind test standard.;The most significant and unexpected finding was partially unsealed shingles on field, hip, and ridge locations on Florida and Texas homes. Location on the shingle's sealant strip where unsealed and failure mode were consistent at each location. Total quantity of partially unsealed shingles in the field of the roof significantly increased with age, aligning with damage statistics. Full-scale wind tunnel tests demonstrate partially unsealed shingles are more vulnerable than fully sealed due to increased distributed force on sealant strip and concentrated force at the adhered and non-adhered interface.;Uplift resistance was measured in artificially and naturally aged shingles. For artificially aged shingles, one of three products evaluated had statistically significant decreases in mean uplift resistance as exposure time increased. However, resistance was above design-level at all exposure test intervals. Naturally aged shingles also had resistance above design-level. Combined results demonstrate that reduced uplift capacity can occur, but high initial bond strength promotes long-term uplift resistance.;Wind loads exerted on the shingles sealant strip load path were directly measured on fully sealed and partially unsealed three-tab and laminate shingles. Results indicate that ASTM D7158 and load model is conservative in force prediction for fully sealed shingles. ASTM D7158 is not conservative for partially unsealed shingles.;Research concludes that partially unsealed shingles occur naturally and represent a large contributor to wind damage. Retrofit of existing shingle roofs and further work identifying specific cause will provide significant reduction of wind risk in shingle roofing.